Product ID:M/M FIX ALL, 5844
MSDS Date:09/01/1989
FSC:8040
NIIN:00N022965
MSDS Number: BLVXM

MANTEK DIV OF NCH CORP

IRVING, TX 75015
US

Emergency Phone: 214-438-1381

Info Phone: 214-438-1381

Preparer: RICHARD STOLLEY

Cage: GO368

NCH CORP / MANTEK DIV

152170 IRVING, TX 75015-2170 US

Telephone: 800-527-9919

Cage: 64796

MAINTENANCE (SUCH AS FERTILIZERS & HERBICIDES), OR

RTECS: 9999999ZZ

NORMAL USE OF PRODUCT DOES NOT REQUIRE THE USE

RTECS: 9999999ZZ

VENTILATION OR OTHER CONTROLS NECESSARY TO MAINTAIN

RTECS: 9999999ZZ

TOLUENE (SARA III)

CAS: 108-88-3

RTECS: XS5250000

OSHA PEL 200 PPM/150 STEL

ACGIH TLV: 50 PPM; 9293

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

STYRENE POLYMER WITH 1,3-BUTADIENE; (THERMOPLASTIC RUBBER)

CAS: 9003-55-8

RTECS: WL6478000

INERT RESIN I

CAS: 9011-11-4

VM & P NAPHTHA

CAS: 64742-89-8

OSHA PEL 300 PPM;400 PPM STEL

ACGIH TLV: 300 PPM

DEPENDING ON THE AMT

RTECS: 9999999ZZ

COMPONENTS, GASTRIC LAVAGE SHLD BE CONSIDERED. KEEP

RTECS: 9999999ZZ

IF COMATOSE, A CUFFED ENDOTRACHEAL TUBE WILL

RTECS: 9999999ZZ

THE PROD IS USED & LBLD FOR ROUTINE JANITORIAL

RTECS: 9999999ZZ

LD50 LC50 Mixture:LD50: ORL(RAT)=5000 MG/KG (FOR TOLUENE)
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYE: MILD IRRIT, REDNESS &
DISCOMFORT. SKIN: SHORT CONTACT USUALLY IS NOT IRRIT. HOWEVER,
PERSONS W/SENSITIVE SKIN MAY BE AFFECTED. INHAL: CAN LEAD TO CNS
DEPRESSION, HDACH, DIZZ, NAUS, & LOSS OF CONSCIOUSNESS. INGEST:
SINGLE DOSE ORAL TOXICITY IS LOW. ALTHOUGH IT COULD CAUSE NAUSEA &
GI IRRIT (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: & ASPIRATION OF MATERIAL COULD LEAD
TO CHEMICAL PNEUMONIA. CHRONIC: SKIN: CONTACT CAN CAUSE IRRITATION
& CAN LEAD TO DERMATITIS. EYE: CONTACT CAN CAUSE MARKED IRRITATION
& MAY LEAD TO CONJUN CTIVITIS. INHAL: CAN LEAD TO NARCOSIS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:INHAL: GET OUT OF CONTAM AREA TO FRESH AIR & TREAT
SYMPTOMATICALLY. IF BRTHG HAS STOPPED, ARTF RESP SHLD BE STARTED.
O*2 SHLD BE ADMINISTERED IF READILY AVAIL. SEEK MED ATTN. EYE:
IMMED FLUSH W/COPIOU S AMTS OF WATER FOR A MINIMUM OF 15 MIN,
HOLDING EYELIDS APART TO ENSURE FLUSHING OF THE ENTIRE EYE SURF.
SEEK MED ATTN. SKIN: WASH W/SOAP & WATER. APPLY A SOOTHING EMOLIENT
CREAM TO IRRITATED(SUPDAT)

Flash Point Method:TCC
Flash Point:40.0F,4.4C
Extinguishing Media:FOAM, ALCOHOL FOAM, CO*2, DRY CHEMICAL, WATER
SPRAY.
Fire Fighting Procedures:FLAMMABLE! WEAR NIOSH/MSHA APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT . EVACUATE ALL UNPROTECTED PERSONNEL.
Unusual Fire/Explosion Hazard:SPRAY EXPOSED CONTAINERS WITH WATER TO
PREVENT BUILDUP OF PRESSURE WHICH COULD CAUSE A RUPTURE.

Spill Release Procedures:FLAMMABLE! ELIMINATE ALL SOURCES OF IGNITION.
HANDLING EQUIPMENT MUST BE PROPERLY GROUNDED. PICK UP W/ABSORBANT &
PLACE INTO LABELED CONTAINERS FOR PROPER DISPOSAL.

Handling and Storage Precautions:STORAGE TEMP: 100F MAX; 32F MIN,
INDOOR. USE W/ADEQUATE VENTILATION. KEEP OUT OF REACH OF CHILDREN.
Other Precautions:READ ENTIRE LBL BEFORE USING PROD. THIS PROD CONTAINS
CHEM (TOLUENE) SUBJECT TO REPORTING REQS OF 313 TITLE III OF SARA
1986 & 40 CFR 372. IF USE EXEMPTION APPEARS UNDER UPPER % LIMIT,
END USERS ARE E XEMPT FROM NOTIFICATION BECAUSE (ING# 8)

Respiratory Protection:IN ABSENCE OF PROPER ENVIRON CTLS: USE
NIOSH/MSHA APPRVD SCBA (COMPRESSED OXYGEN SHLD NOT BE USED IN TANKS
OR OTHER CONFINED AREAS), POSITIVE-PRESSURE HOSE MASK, AIR LINE
MASKS, & INDUSTRIAL CANSISTER TYPE ORGANIC VAPOR MASK. (ING# 10)
Ventilation:GOOD INDUS HYGIENE PRAC DICTATES THAT THE WORK AREA SHLD BE
ISOLATED/CONTAINED, & PROVIDED W/ADEQ LOCAL EXHST (ING# 11)
Protective Gloves:NEOPRENE GLOVES.
Eye Protection:CHEM WORK GOGG/FULL LENGTH FSHLD .
Other Protective Equipment:NOT REQUIRED.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRST AID PROC: SKIN AFTER CLEANSING. THE MILD BUT TRANSIENT IRRIT
WHICH MAY RSLT SHLD BE BROUGHT TO THE ATTN OF AN MD IF IRRIT
PERSISTS. INGEST: IF SWALLOWED, DO NOT INDUCE VOMIT. IF VOMIT
OCCURS SPO NT, POSITION THE PERSON'S HEAD SO AS TOKEEP THE AIRWAY
CLEAR. NEVER GIVE ANYTHING BY MOUTH TO AN UNCON PERSON. (ING# 5)

HCC:F3
Boiling Pt:B.P. Text:231F,111C
Vapor Pres:22
Vapor Density:3.2
Spec Gravity:0.9
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR, COLORLESS MIXTURE WITH AROMATIC ODOR.
Percent Volatiles by Volume:67

Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:AVOID OPEN FLAMES, WELDING ARCS OR HIGH
TEMPERATURES SOURCES WHICH INDUCE THERMAL DECOMPOSITION.
Hazardous Decomposition Products:CO AND TRACES OF OTHER ORGANIC
COMPOUNDS.

Waste Disposal Methods:DISPOSE OF I/A/W ALL LOCAL, STATE, AND FEDERAL
REGULATIONS REGARDING HEALTH & POLLUTION. GENERALLY, THE TUBE CAN
BE EMPTIED, WRAPPED IN NEWSPAPER & DISCARDED IN THE TRASH.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.